Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Optimization of Astrazon Blue Adsorption onto Sulfunated Styrene-co-divinylbenzene Resin by Experimental Design Methodology

Document Type : Research Article

Authors
Mohsen Ghorbani
Abbas Bagherian
Faculty of Chemical Engineering, Babol University of Technology, P.O.Box 484, Babol, I.R. IRAN
Abstract
Finding the perfect absorbent for the removal of a color with higher absorbent capacity and attract more colors, and determining the optimum conditions for the use of absorbent for textile factories and the environment is of particular importance. The purpose of this study was to evaluate and optimize the adsorption of Astrazon blue cationic dye from aqueous solution using sulfunated styrene-co-divinylbenzene resin. The variable amount of time, the adsorbent dosage and dye concentration were optimized by experimental design method. Numbers of 15 experiment was designed with Response Surface Methodology (RSM) and use the Box-Behnken design (Box-Behnken) with Design Expert 7.0.0 Trial software by three factors: time, adsorbent dosage and dye concentration in three levels (+1, 0, 1) with three- center points. Each experiment was done with a certain dose of adsorbent in 10 mL solution containing cationic dye and the dye adsorbed was measured.
Keywords
Adsorption
Sulfonated poly(styrene-co-divinylbenzene)
Astrazon blue cationic dye
Response surface methodology
Box-Behnken Design

Subjects

[1] عبدالشاهی نژاد، سارا؛ برقعی، سید مهدی؛ سیدی، مجتبی؛ حذف کروم شش ظرفیتی توسط نانو ذره­های فریت، نشریه شیمی و مهندسی شیمی ایران، (1)34 : 29 تا 37 (1394).
[2] Somasiri W., Li X-F., Ruan W., Jian Ch., Evaluation of the Efficacy of  Up-Flow Anaerobic Sludge Blanket Reactor in Removal of Color and Reduction of COD in Real Textile Wastewater, Bioresource Technology, 99 (9): 3692-3699 (2007).
[3] Crini G., Non-Conventional Low-Cost Adsorbents for Dye Removal: A Review,Bioresour. Technol., 97: 1061–1085 (2006).
[4] Gupta V.K., Suhas, Application of Low-Cost Adsorbents for Dye Removal--A Review, J. Environ. Manage., 90: 2313-2342 (2009).
[5] Forgacs E., Cserhati T., Oros G., Removal of Synthetic Dyes from Wastewaters: A Review, Environ. Int., 30: 953–971 (2004).
[6] Rai H.S., Bhattacharyya M.S., Singh J., Bansal T.K., Vats P., Banerjee U.C., Removal of Dyes from the Effluent of Textile and Dyestuff Manufacturing Industry: A Review of Emerging Techniques  with Reference to Biological Treatment, Crit. Rev. Environ. Sci. Technol., 35: 219-238 (2005).
[7] Pearce C.I., Lloyd J.R., Guthrie J.T., The Removal of Colour from Textile Wastewater Using Whole Bacterial Cells: A Review, Dyes Pigm., 58: 179-196 (2003).
[8] McMullan G., Meehan C., Conneely A., Kirby N., Robinson T., Nigam P., Banat I., Marchant R., Smyth W., Microbial Decolourisation and Degradation of Textile Dyes, Appl. Microbiol. Biotechnol., 56: 81–87 (2001).
[9] Anbia M., Salehi S., Removal of Acid Dyes from Aqueous Media by Adsorption onto Amino-Functionalized Nanoporous Silica SBA-3, Dyes Pigm., 94: 1–9 (2012).
[10] Huang X.-Y., Mao X.-Y., Bu H.-T., Yu X.-Y., Jiang G.-B., Zeng M.-H., Chemical Modification of Chitosan by Tetraethylenepentamine and Adsorption Study for Anionic Dye Removal, Carbohydr. Res., 346: 1232–1240 (2011).
[11] Figueiredo J.L., Pereira M.F.R., "Novel Carbon Adsorbents", in: J.M.D. Tascَn (Ed.), Elsevier, Oxford, pp. 471–498 (2012).
[12] Li J.T., Li B.L., Wang H.C., Bian X.B., Wang X.M., A Wormhole-Structured Mesoporous Carbon with Superior Adsorption for Dyes, Carbon, 49: 1912–1918 (2011).
[13] Beltran de Heredia J., Dominguez J.R., Lَpez R., Treatment of Cork Process Wastewater by a Successive Chemical−Physical Method, J. Agric. Food Chem., 52: 4501-4507 (2004). 
[14] Parasuraman D., Serpe M.J., Poly (n-Isopropylacrylamide) Microgels for Organic Dye Removal from Water , ACS Appl. Mater. Interfaces, 3: 2732–2737 (2011).
[15] Caiizares P., Mart Nez F., Jiménez C., Lobato J., Rodrigo M.A., Coagulation and Electrocoagulation of Wastes Polluted with Dyes, Environ. Sci. Technol., 40: 6418-6424 (2006).
[16] Kartal B., Kuenen J.G., van Loosdrecht M.C.M., Sewage Treatment with Anammox, Science, 328: 702–703 (2010).
[17] Juang R.-S., Shiau R.-C., Metal Removal from Aqueous Solutions Using Chitosan-Enhanced Membrane Filtration , J. Membr. Sci., 165: 159–167 (2000).
[18] Wang S., Li H., Xu L., Application of Zeolite MCM-22 for Basic Dye Removal from Wastewater, J. Colloid Interface Sci., 295: 71–78 (2006).
[19] Li L., Liu S., Zhu T., Application of Activated Carbon Derived from Scrap Tires for Adsorption of Rhodamine B,  J. Environ. Sci., 22: 1273-1280 (2010).
[20] Pereira M.F.R., Soares S.F., Rfo J.J.M., Figueiredo J.L., Adsorption of Dyes on Activated Carbons: Influence of Surface Chemical Groups, Carbon, 41: 811– 821 (2003).
[21] Guedidi H., Reinert L., Lévêque J.-M., Soneda Y., Bellakhal N., Duclaux L., The Effects of the Surface Oxidation of Activated Carbon, the Solution pH and the Temperature on Adsorption of Ibuprofen, Carbon, 54: 432–443 (2013).
[22] Al-Ghouti M.A., Khraisheh M.A.M., Allen S.J., Ahmad M.N., The Removal of Dyes from Textile Wastewater: A Study of the Physical Characteristics and Asorption Mechanisms of Diatomaceous Earth, J. Environ. Manage., 69: 229-238 (2003).
[23] Lin J.X., Zhan S.L., Fang M.H., Qian X.Q., The Adsorptionof Dyes from Aqueous Solution Using Diatomite, J. Porous Mater., 14: 449-455 (2007).
[24] Huang C.-H., Chang K.-P., Ou H.-D., Chiang Y.-C., Wang C.-F., Adsorption of Cationic Dyes onto Mesoporous Silica , Micropor. Mesopor. Mater., 141: 102–109 (2011).
[25] Wang S., Li H., Structure Directed Reversible Adsorption of Organic Dye on Mesoporous Silica in Aqueous Solution, Micropor. Mesopor. Mater., 97: 21–26 (2006).
[26] Dong Y., Lu B., Zang S., Zhao J., Wang X., Cai Q., Removal of Methylene Blue from Coloured Effluents by Adsorption onto SBA-15, J. Chem. Technol. Biotechnol., 86: 616–619 (2011).
[27] Chen Z., Zhou L., Zhang F., Yu C., Wei Z., Multicarboxylic Hyperbranched Polyglycerol Modified SBA-15 for the Adsorption of Cationic Dyes and Copper Ions from Aqueous Media , Appl. Surf. Sci., 258: 5291–5298 (2012).
[28] Garcia-Diego C.,; Cuellar J., Synthesis of Macroporous Poly(styrene-co-divinylbenzene) Microparticles Using n-Heptane as the Porogen: Quantitative Effects of the DVB Concentration and the Monomeric Fraction on Their Structural Characteristics, Ind. Eng. Chem. Res., 44: 8237-8247 (2005).
[29] Garcia-Diego C., Cuellar J. , Determination of the Quantitative Relationships between the Synthesis Conditions of Macroporous Poly(styrene-co-divinylbenzene) Microparticles and the Characteristics of Their Behavior as Adsorbents Using Bovine Serum Albumin as a Model Macromolecule, Ind. Eng. Chem. Res., 45: 3624-3632 (2006).
[30] Martin C., Cuellar J., Synthesis of a Novel Magnetic Resin and the Study of Equilibrium in Cation Exchange with Amino Acids, Ind,  Eng, Chem, Res, 43: 475-485 (2004).
[31] Juang R.,  Swei S., Effect of dye Nature on Its Adsorption from Aqueous Solution onto Activated Carbon, Sep. Sci. Technol., 31(15): 2143-2158 (1996).
[32] Rathi P., Saxena R.K., Gupta R., A Novel Alkaline Lipase from Burkholderia Cepacia for Detergent Formulation, Process. Biochem., 37: 187–192 (2001).
[33] Chang Y.C., Lee C.L., Pan T.M., Statistical Optimization of Media Components for the Production of Antrodia Cinnamomea AC0623 in Submerged Cultures, App. Microbiol. Biotechnol., 72: 654–661 (2006).
[34] Chakravarti R., Sahai V., Optimization of Compactin Production in Chemically Defined Production Medium by Penicillium Citrinum Using Statistical Methods, Process Biochemistry, 38: 481–486 (2002).
[35] Cojocaru C., Zakrzewska-Trznadel G., Response Surface Modeling and Optimization of Copper Removal from Aqua Solutions Using Polymer Assisted Ultrafiltration, J. Membrane Sci., 298: 56–70 (2007).
[36] ozer A., Gürbüz G., alimli A. C., Korbahti B.K., Biosorption of Copper(II) Ions on Enteromorpha Prolifera: Application of Response Surface Methodology (RSM), Chem. Eng. J., 146: 377–387 (2009). 
[37] Khattar J.I.S., Shailza, Optimization of Cd2+ Removal by the Cyanobacterium Synechocystis Pevalekii Using the Response Surface Methodology, Process Biochem., 44: 118–121 (2009).
[38] Montgomery D.C., "Design and Analysis of Experiments", fifth ed., John Wiley & Sons, New York, (2001).
[39] Clarke G.M., Kempson R.E., "Introduction to the Design and Analysis of Experi- Ments", Arnold, London, (1997).
[40] Cornell J.A., "Howto Apply Response Surface Methodology", second ed., American Society for Quality Control, Wisconsin, (1990).
[41] Box G., Draper N., "Empirical Model Building and Response Surfaces", John Wiley & Sons, New York, (1987).
[42] Box G.E.P., Behnken D.W., Some New Three Level Designs for the Study of Quantitative Variables, Technometrics, 2: 455-475 (1960).
[43] Ferreira S.L.C., Bruns R.E., Ferreira H.S., Matos G.D., David J.M., Brandäo G.C., Da Silva E.G.P., Portugal L.A., Dos Reis P.S., Souza A.S., Dos Santos W.N.L., Box-Behnken Design: An Alternative for the Optimization of Analytica Methods, Analytica Chimica Acta, 597: 179-186 (2007).
[44] Box G.E.P., Draper N.R., "Empirical Model Building and Response Surfaces", John Wiley and Sons, New York,( 1987).
[45] Kamarei F., Ebrahimzadeh H., Yamini Y., Optimization of Solvent Bar Microextraction Combined with Gas Chromatography for the Analysis of Aliphatic Amines in Water Samples, J. Hazard. Mater., 178: 747–752 (2010).
[46] Mottahedin P., Haghighiasl A., Subcritical Water as a Solvent and Its Application for Extraction, Journal of Applied Researches in Chemistry (JARC), 7: 59-81 (2013).
[47]سردشتی، علیرضا ؛ محمدیان مقدم، سعید؛ تعیین ظرفیت تبادل کاتیونی هیومیک اسید استخراج شده از خاک جنگلی نهار خوران گرگان ، نسبت به یون های pb2+، Cd2+ و Ni2+ به روش ناپیوسته ظرفی در محیط آبی، نشریه شیمی و مهندسی شیمی ایران، (3) 26 : 9 تا 17 (1386).
[48] Karagozoglu  B. , Tasdemir M., Demirbas E.,  Kobya  M., The Adsorption of Basic Dye (Astrazon Blue FGRL) from Aqueous Solutions onto Sepiolite, Fly Ash and Apricot Shell Activated Carbon: Kinetic and Equilibrium Studies, J. Hazard. Mater., 147(1-2): 297-306 (2007).
[49] Lacramioara R., Maria H., Andrei I., Daniela S., Gabriela C., Lidia F., Removal of Astrazone Blue from Aqueous Solutions onto Brown Peat. Equilibrium and Kinetics Studies, Kor. J. Chem. Eng., 31(6): 1008-1015 (2014).
[50] Khanidtha M., Prasert P., Removal of Basic Dye (Astrazon Blue FGRL) Using Macroalga Caulerpa Lentillifera, J. Environ. Manag., 78(3): 268-274 (2006).
[51] سردشتی، ذبیح الله؛ گنجی دوست، حسین؛ آیتی، بیتا؛ حذف رنگ از محلول آبی با خاک اره و رس بنتونیت، نشریه عمران مدرس، (3)11: مقاله 7 (1390).
[52] Rajendran A., Thangavelu V., Sequential Optimization of Culture Medium Composition for Extracellular Lipase Production by Bacillus Sphaericus Using Statistical Methods, J. Chem. Technol. Biotechnol, 82: 460–470 (2007).