Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Sphalerite Separation from the Tailings of Kooshk Lead-Zinc Mine Using Flotation Method

Document Type : Research Article

Authors
Behnam Bagheri 1
Javad Vazifeh Mehrabani 2
1 Depatment of Mining Engineering, Sahand University of Technology, Tabriz, I.R. IRAN
2 Department of Mining Engineering, Sahand University of Technology, Tabriz, I.R. IRAN
Abstract
In this research work, selective separation of sphalerite from Kooshk mine accumulated tailings were evaluated by the flotation method. Besides the high amount of sphalerite, the presence of carbonaceous matters and a high amount of pyrite (about 50%) were two main features of prepared tailings. In the test conditions of 15g/t collector and pulp natural pH, experimental results indicated that the highest grade and sphalerite recovery achieved by Aero3477 among different collectors of PAX، ، Florrea 2214 و Danafloat 233. In which condition, pyrite had the lowest floatability in the rougher stage. Increasing collector dosage to 40 g/t Zn grade and recovery obtained 24.27% and 68.89% respectively. Unlike PAX collector, in the presence of Aero3477, increasing flotation pulp pH not only depressed pyrite but also pyrite floated considerably in the alkaline pH, in comparison to acidic pulp condition. In addition, it was concluded that in the alkaline condition, pulp viscosity increased, as a result, sphalerite floatability and separation efficiency dropped significantly. The obtained results could be referred to as the side effect of gypsum and some clay minerals on the sphalerite surface and also flotation pulp rheology.
Keywords
Flotation
Tailing
Sphalerite
Pyrite
Collector type

Subjects

[1] Bulatovic S. M., "Handbook of Flotation Reagents- Chemistry, Theory and Practice- Flotation of Sulfide Ores", Vol. 1, pp.325-349 (2007).
[2] Gredelj S., Zanin M., Grano S.R., Selective  flotation of carbon in the  Pb-Zn carbonaceous sulphide ores of Century Mine, Zinifex, Minerals Engineering 22, pp.279-288 (2009).
[3] Basilio C.I., Kartio I.J., Yoon R. H., Lead activation of sphalerite during galena flotation, Minerals Engineering, pp. 869–879 (1996).
[4] Boulton A., Fornasier D., Ralston, J., Depression of iron sulphide flotation in zinc roughers, Minerals engineering, Vol.14, No.9, pp. 1067-1079 (2001).
[5] Mu Y., Peng Y., Lauter R.A., The depression of pyrite in selective flotation by different reagent system- A Literature review, Minerals Engineering 96-97, pp.143-156 (2016).
[6] Chandra A.P., Gerson A.R., The mechanisms of pyrite oxidation and leaching: A fundamental perspective, Sience Reports 65, pp. 293-315 (2010).
[7] Lopez Valdivieso A., et al., Dextrin as a non-taxic depressant for pyrite in flotation with xanthates as collector, Minerals Engineering 17. pp. 1001-1006 (2004).
[8] Bulatovic S. M., "Handbook of Flotation Reagents- Chemistry, Theory and Practice- Flotation of Sulfide Ores", Vol. 1, pp.153-184 (2007).
[9] Klassen V.I., Mokrousov V. A., "An Introduction to the Theory of Flotation", Butterworth and Co. Ltd., London (1963).
[10] Guo B., Peng Y., Espinosa-Gomez R., Cyanide chemistry and its effect on mineral flotation, Minerals Engineering 66-68, pp. 25-32 (2014).
[11] Khmeleva T.N., Skinner W., Beattie, D.A., Georgiev, T. V., The effect of sulphide on the xanthate-induced flotation of cpper-activated pyrite, Physicochemical problems of mineral processing 36, pp. 185-195 (2002).
[12] Tapley B., Yan D., The selective flotation of arsenopyrite from pyrite, Minerals Engineering 16,  pp. 1217–1220 (2003).
[13] Pencina-Trevinno E.T., Uribe-Salas A., Nava-Alonso F., Perez-Garibay R., On the sodium-diisobutyle dithiophosphinate (Aerophine 3418A) intraction with activated and unactivated galena and pyrite, Int. J. Miner. Process71, pp. 201-217 (2003).
 [14] Cytec., "Mining Chemicals Handbook", Revised edition (2002).
[15] رجائی م.م.؛ مطالعه و بررسی بازیابی روی از باطله­های کارخانه­ی فرآوری سرب و روی کوشک ، پروژه­ی کارشناسی ارشد، دانشگاه تهران، (1390).
[16] Patra P., Nagaraj D.R., Somasundaran P., Impact of pulp rheology on selective recovery of value minerals from ores, Proceedings of the XI International seminar on Mineral Processing Technology (MPT-2010), pp. 1223-1231 (2010).
[17] Zhang M., Peng Y., Effect of clay minerals on pulp rheology and the flotation of copper and gold minerals, Minerals Engineering 70, pp. 8-13 (2015).
[18] Ndlovu B., Becker M., Forbes E., Deglon D., Franzidis J.P., The influence of phyllosilicate mineralogy on the rheology of mineral slurries, Minerals Engineering 24 ,pp.1314–1322 (2011).
[19] Luckham P.F., Rossi S., The colloidal and rheological properties of bentonite suspensions, Adv. Colloid Interf. Sci. 82 (1–3), pp.43–92 (1999).
[20] Davila-Pulido G.I., Uribe-Salas, A., Effect of calcium, sulphate and gypsum on copper-activated and non-activated sphalerite surface properties, Minerals Engineering 55, pp.147-153 (2014).
[21] Deng M., Liu Q., Xu Zh., Impact of gypsum supersaturated water on the uptake of copper and xanthate on sphalerite, Minerals Engineering 49, pp.165-171 (2013).
[22] حیدری ق.؛ بهینه­سازی مدار شناورسازی کارخانه­ی فرآوری سرب و روی کوشک، پروژه­ی کارشناسی ارشد، دانشگاه صنعتی سهند تبریز، (1395).
[23] Bogusz E. J., The mechanism of the depressant action of dextrin on pyrite. M.Sc. Thesis, McGill university  (1995).