Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Evaluation of the Efficiency of Natural Clinoptilolite Zeolites in the Removal of Magnesium Ions from Aqueous Solution

Document Type : Research Article

Authors
Hadiseh Masoomi
Sakine Redaei
Hossein Ghannadzadeh Gilani
Department of Chemical Engineering, Faculty of Engineering, University of Guilan, Rasht, I.R. IRAN
Abstract
In this research, the adsorption of Mg (II) was studied in a batch system by using zeolite, and the influence of effective parameters on the adsorption, such as initial pH, adsorbent dosage, contact time, initial Mg (II) concentration and temperature were investigated. Also, the surface characteristics and structure of the adsorbents were respectively obtained by SEM and FT-IR. The pH experimental results showed that the maximum adsorption efficiency of Mg (II) ion occurs at pH=7. By increasing the contact time between the adsorbent and solution, adsorption efficiency was raised, and after 60 minutes, equilibrium is reached. Results showed the adsorption efficiency decreased by increasing the initial concentrations of Mg (II) in the range of 50-250 ppm in solution, and the effect of adsorbent dosage showed that adsorption efficiency increased by increasing the adsorbent dosage from 0.5g to 2.5g. In addition, the higher adsorption of Mg (II) was observed at higher temperatures, which proves the endothermic behavior of the adsorption process. Thermodynamic parameters were investigated in three temperatures 25, 35, and, 45°Ϲ. The negative value of the Gibbs free energy (ΔG˚) showed that the adsorption process was spontaneous. Positive value enthalpy (ΔH˚) indicated that the adsorption process was endothermic, and positive value entropy (ΔS˚) can be attributed to the increased randomness at the interface of the adsorbent and the solution. The experimental results for the effect of exposure time were examined for the kinetic study with three different models: Pseudo-First order, Pseudo-Second order, and Intra-Particle diffusion. Among these models, the best fit was observed for pseudo-second-order. The study for initial concentration of Mg (II) in the solution was studied by Langmuir, Freundlich, Temkin, and Dubnin-Radushkevich isotherms, and the best fit for the adsorbent was observed by Langmuir isotherm and the Langmuir maximum sorption capacity was found to be 4.77 mg/g at 45°C.
Keywords
Adsorption
Zeolite
Adsorption Isotherm
Adsorption Kinetic
Magnesium
Capacity of sorption
Percentage of sorption

Subjects

[1] Friedrich H.E., Mordike B.L., "Magnesium Technology". Springer (2006).
[2] منصور پناه ی.، دینکی ع.، کاکانژاد ع.، ملاتقی ع.، تصفیه آب و پساب، انتشارات منشور سیدی، 100 (1384).
[3] Kulekci M.K., Magnesium and its Alloys Applications in Automotive Industry. The International Journal of Advanced Manufacturing Technology, 39(9-10): 851-865 (2009).
[4] Poots V., McKay G., Healy J., The Removal of Acid Dye from Effluent Using Natural Adsorbents—I. Water Research, 10(12): 1061-1066 (1976).
[5] Mordike B., Ebert T., Magnesium: Properties—Applications—Potential. Materials Science and Engineering: A. 302(1): 37-45 (2001).
[6] Sengupta P., Potential Health Impacts of Hard Water. International Journal of Preventive Medicine, 4(8): 866-875 (2013).
[7] Branch C.,  Mueller-Steinhagen H., Influence of Scaling on the Performance of Shell-and-Tube Heat Exchangers. Heat Transfer Engineering, 12(2): 37-45 (1991).
[8] Gabrielli C.,  Jaouhari R., Maurin G., Keddam M., Magnetic Water Treatment for Scale Prevention. Water Research, 35(13): 3249-3259 (2001).
[9] Fu L., Wang J., Su Y., Removal of Low Concentrations of Hardness Ions from Aqueous Solutions using Electrodeionization Process. Separation and Purification Technology, 68(3): 390-396 (2009).
[10] Park J.S., Song J.H., Yeon K.H., Moon S.H., Removal of Hardness Ions from Tap Water using Electromembrane Processes. Desalination, 202(1-3): 1-8 (2001).
[11] Bailey S.E., Olin T.J., Bricka R.M., Adrian D.D., A Review of Potentially Low-Cost Sorbents for Heavy Metals. Water Research, 33(11): 2469-2479 (1999).
[12] Egila J., Dauda B.E.N., Iyaka Y.A., Jimoh T., Agricultural Waste as a Low Cost Adsorbent for Heavy Metal Removal from Wastewater. International Journal of Physical Sciences, 6(8): 2152-2157 (2011).
[13] Montazeri, N., Baher E., Brami Z., Ghourchi M., The Role of Kiwi in Eliminatron of Pollution and Factors Affacting it (Case Study in Tonekabon). Journal of Sciences And Techniques In Natural Resources, 5(1): 117-128 (2010).
[14] Sekar M., Sakthi V., Rengaraj S., Kinetics and Equilibrium Adsorption Study of Lead (II) Onto Activated Carbon Prepared from Coconut Shell. Journal of Colloid And Interface Science, 279(2): 307-313 (2004).
[15] Ho Y., McKay G., The Sorption of Lead (II) Ions on Peat. Water Research, 33(2): 578-584 (2001).
[16] Moscatello N., Swayambhu G., Jones C.H., Xu J., Dai N., Pfeifer B.A., Continuous Removal of Copper, Magnesium, and Nickel from Industrial Wastewater Utilizing the Natural Product Yersiniabactin Immobilized within a Packed-Bed Column. Chemical Engineering Journal, 343: 173-179 (2018).
[17] Zheng F.-Q., Guo Y.F., Liu S.S., Qiu G.Z., Chen F., Jiang T., Wang S., Removal of Magnesium and Calcium from Electric Furnace Titanium Slag by H3PO4 Oxidation Roasting–Leaching Process. Transactions of Nonferrous Metals Society of China, 28(2): 356-366 (2018).
[18] Li, Z., Mercken J., Li X., Riaño S., Binnemans K., Efficient and Sustainable Removal of Magnesium from Brines for Lithium/Magnesium Separation using Binary Extractants. ACS Sustainable Chemistry & Engineering, 7(23): 19225-19234 (2019).
[19] Cahyaningrum S.E., Narsito a., Santoso S.J., Agustini R., Adsorption of Mg (II) Ion from Aqueous Solution on Chitosan Beads and Chitosan Powder. Journal of Coastal Development ISSN, 13(3): 179-184 (2010).
[20] Sepehr M.N., Zarrabi M., Kazemian H., Amrane A., Yaghmaian K., Ghaffari H.R., Removal of Hardness Agents, Calcium and Magnesium by Natural and Alkaline Modified Pumice Stones in Single and Binary Systems. Applied Surface Science, 274: 295-305 (2013).
[21] Saeed A.M., Hamzah M.J., New Approach for Removal of Total Hardness (Ca+2, Mg+2) from Water Using Commercial Polyacrylic Acid Hydrogel Beads, Study and Application. International Journal of Advanced Biological and Biomedical Research, 1(9): 1142-1156 (2013).
[22] Al-Anber M., Al-Anber Z.A., Utilization of Natural Zeolite as Ion-Exchange and Sorbent Material in the Removal of Iron. Desalination, 225(1-3): 70-81 (2008).
[23] Oei B.C., Ibrahim S., Wang S., Ang H.M., Surfactant Modified Barley Straw for Removal of Acid and Reactive Dyes from Aqueous Solution. Bioresource Technology, 100(18): 4292-4295 (2009).
[24] Chang W.-S., Hong S.-W., Park J., Effect of Zeolite Media for the Treatment of Textile Wastewater in a Biological Aerated Filter. Process Biochemistry, 37(7): 693-698 (2002).
[25] Hashem A., Adam E., Hussein H.A., Sanousy M.A., Ayoub A., Bioadsorption of Cd (II) from Contaminated Water on Treated Sawdust: Adsorption Mechanism and Optimization. Journal of Water Resource and Protection, 5(1): 82-90 (2013).
[26] Castaldi P., Santona L., Cozza C., Giuliano V., Abbruzzese C., Nastro V., Melis P., Thermal and Spectroscopic Studies of Zeolites Exchanged with Metal Cations. Journal of Molecular Structure, 734(1-3): 99-105.
[27] Li X.,  Yang W., Zou Q., Zuo Y., Investigation on Microstructure, Composition, and Cytocompatibility of Natural Pumice for Potential Biomedical Application. Tissue Engineering Part C: Methods, 16(3): 427-434 (2009).
[28] Panuccio M.R., Sorgonà A., Rizzo M., Cacco G., Cadmium Adsorption on Vermiculite, Zeolite and Pumice: Batch Experimental Studies. Journal of Environmental Management, 90(1): 364-374 (2009).
[29] Motsi T., Rowson N., Simmons M., Adsorption of Heavy Metals from Acid Mine Drainage by Natural Zeolite. International Journal of Mineral Processing, 92(1-2): 42-48 (2009).
[30] Sekhar K.C., Kamalaa C.T, Charya N.S., Anjaneyulu Y., Removal of Heavy Metals using a Plant Biomass with Reference
to Environmental Control. International Journal of Mineral Processing, 68(1-4): 37-45 (2003).
[31] قنادزاده گیلانی ح.، قنادزاده گیلانی ع.، آزمون  پ.، بررسی جذب فنل از محلول های آبی با استفاده از کربن هسته انار. نشریه شیمی و مهندسی شیمی ایران، (4)36: 145 تا 159 (1396).
[32] Bohli T., Gill I.V., Santalo N.F., Quederni A.,  Adsorption on Activated Carbon from Olive Stones: Kinetics and Equilibrium of Phenol Removal from Aqueous Solution, Journal of Chemical Engineering and Process Technology, 4(6): 165-175 (2013).
[33] Ho Y.-S., McKay G., Pseudo-Second Order Model for Sorption Processes. Process Biochemistry, 34(5): 451-465 (1999).
[34] Hameed B., Rahman A., Removal of Phenol from Aqueous Solutions by Adsorption onto Activated Carbon Prepared from Biomass Material. Journal of hazardous materials, 160(2-3): 576-581 (2008).
[35] Amin N.K., Removal of Direct Blue-106 Dye from Aqueous Solution Using New Activated Carbons Developed from Pomegranate Peel: Adsorption Equilibrium and Kinetics. Journal of Hazardous Materials, 165(1-3): 52-62 (2009).
[36] Holan8, Z.n., Volesky B.N., Accumulation of Cadmium, Lead, and Nickel by Fungal and Wood Biosorbents. Applied Biochemistry and Biotechnology, 53(2):133-146 (1995).
[37] Calero  M., Pérez A., Blázquez G., Ronda A., Angeles M., Lara M., Characterization of Chemically Modified Biosorbents from Olive Tree Pruning for the Biosorption of Lead. Ecological Engineering, 58: 344-354 (2013).
[38] Özacar M., Şengil İ.A., Adsorption of Metal Complex Dyes from Aqueous Solutions by Pine Sawdust. Bioresource Technology, 96(7): 791-795 (2005).
[39] Rawajfih Z., Nsour N., Thermodynamic Analysis of Sorption Isotherms of Chromium (VI) Anionic Species on Reed Biomass. The Journal of Chemical Thermodynamics, 40(5): 846-851 (2008).
[40] Shukla A., Zhang Y.H., Dubey P., Margrave J.L., Shukla S., The Role of Sawdust in the Removal of Unwanted Materials from Water. Journal of Hazardous Materials, 95(1-2): 137-152.
[41] Renault F., Morin-Crini N., Gimbert F., Badot P.M., Crini G., Cationized Starch-Based Material as a New Ion-Exchanger Adsorbent for the Removal of CI Acid Blue 25 from Aqueous Solutions. Bioresource Technology, 99(16): 7573-7586 (2009).
[42] FierroV., Fernández V., Montané D., Celzard A., Adsorption of Phenol onto Activated Carbons Having Different Textural and Surface Properties. Microporous and Mesoporous Materials, 111(1-3): 276-284 (2008).
[43] Bouhamed F., Elouear Z., Bouzid J., Adsorptive Removal of Copper (II) from Aqueous Solutions on Activated Carbon Prepared from Tunisian Date Stones: Equilibrium, Kinetics and Thermodynamics. Journal of the Taiwan Institute of Chemical Engineers, 43(5): 741-749 (2012).
[44] Ahmaruzzaman M., Sharma D., Adsorption of Phenols from Wastewater. Journal of Colloid and Interface Science, 287(1): 14-24.
[45] Miao, Q., Tang Y., Xu J., Liu X., Xiao L., Chen Q., Activated Carbon Prepared from Soybean Straw for Phenol Adsorption. Journal of the Taiwan Institute of Chemical Engineers, 44(3): 458-465 (2013).
[46] Jadhav A.J., Srivastava V.C., Adsorbed Solution Theory based Modeling of Binary Adsorption of Nitrobenzene, Aniline and Phenol onto Granulated Activated Carbon. Chemical Engineering Journal, 229: 450-459 (2013).
[47] Foo K.Y., Hameed B.H., Insights into the Modeling of Adsorption Isotherm Systems. Chemical Engineering Journal, 156(1): 2-10 (2010).
[48] Tempkin, M., V. Pyzhev, Kinetics of Ammonia Synthesis on Promoted Iron Catalyst, Acta Physico-Chimica, 12(1): 327-337 (1940).
[49] Dubinin M.M., Zaverina E., Radushkevich L., Sorption and Structure of Active Carbons. I. Adsorption of Organic Vapors. Zhurnal Fizicheskoi Khimii, 21(3): 151-162 (1947).
[50] Helfferich F.G., "Ion Exchange Kinetics--Evolution of a Theory, in Mass Transfer and Kinetics of Ion Exchange”. Springer. 157-179. (1983),
[51] Mittal H., Parashar V., Mishra S.B., Mishra A.K., Fe3O4 MNPs and Gum Xanthan based Hydrogels Nanocomposites for the Efficient Capture of Malachite Green from Aqueous Solution. Chemical Engineering Journal, 255: 471-482 (2014).
[52] Khan A.A., Singh R., Adsorption Thermodynamics of Carbofuran on Sn (IV) Arsenosilicate in H+, Na+ and Ca2+ Forms. Colloids and Surfaces, 24(1): 33-42 (1987).
[53] Klimaviciute R., Bendoraitiene J., Rutkaite R., Zemaitaitis A., Adsorption Of Hexavalent Chromium On Cationic Cross-Linked Starches of Different Botanic Origins. Journal of Hazardous Materials, 181(1-3): 624-632 (2010).
[54] Liu Q.-S.,  Zheng T., Wang P., Jiang J., Li N., Adsorption Isotherm, Kinetic and Mechanism Studies of Some Substituted Phenols on Activated Carbon Fibers. Chemical Engineering Journal, 157(2-3): 348-356 (2010).
[55] Namasivayam C., Ranganathan K., Removal of Cd(II) from Wastewater by Adsorption on “Waste” Fe (III) Cr (III) Hydroxide. Water Research, 29(7): 1737-1744 (1995).
[56] Jain C., Singhal D., Sharma M., Adsorption of Zinc on Bed Sediment of River Hindon: Adsorption Models and Kinetics. Journal of Hazardous Materials, 114(1-3): 231-239 (2004).
[57] Tomić S., Rajic N., Hrenovic J., Povrenović D., Removal of Mg from Spring Water Using Natural Clinoptilolite. Clay Minerals, 47(1): 81-92 (2012).