Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Investigating the Performance of Different Chemicals for Cyanide Substitution in Bama Lead & Zinc Flotation Circuit

Document Type : Research Article

Authors
Sayed Mahdi Namgar 1
Abdorrahim Foroutan 2
Ali Akbar Abdollahzade 3
1 Department of mining engineering, University of Kashan, Kashan, I.R. IRAN
2 School of Mining and Metallurgical Engineering, Yazd University, Yazd, I.R. IRAN
3 Department of Mining Engineering, University of Kashan, Kashan, I.R. IRAN
Abstract
Cyanide is the most commonly depressant for pyrite and sphalerite in lead flotation. Although cyanide is a common and strong depressant, but its usage causes environmental pollution and serious hazards. In this study the performance of three chemical substances include sodium sulphide, sodium metabisulphite and sodium sulphite were investigated in lead flotation of Irankooh ore.Since in Bama plant, sequential flotation is being done and the tailing of lead circuit goes to zinc circuit, the effect of cyanide alternatives on zinc flotation was also investigated. After finding the optimal amount of each chemical substance and comparing its performance with cyanide, it became clear that sodium sulphite can be a suitable alternative for cyanide. In natural pH (8.5) with using 600 g/ton sodium sulphite instead of cyanide in lead flotation of Irankooh ore, lead recovery has increased 2.5% and zinc recovery in lead concentrate decreased 0.7%, against iron recovery increased 1.2% and lead grade decreased 1.5%. In this condition, sodium sulphite had positive effect on zinc flotation and in comparing with the optimal amount of cyanide, Zn recovery and Zn grade increased 1.5% and 1.2% respectively. If lead flotation is done with this amount of sodium sulphite and in pH=9.5, the performance will be quite better and in comparing with current plant performance, in addition of increasing 2.8% in lead recovery, lead grade will be increased 2%.
Keywords
Flotation
Cyanide
lead & zinc
environment
Bama plant
Sodium sulphite

Subjects

[1] Bulatovic S.M., "Handbook of Flotation Reagents: Chemistry, Theory and Practice. Flotation of Sulfide Ores", Vol 1, Elsevier, (2007).
[2] Eisler R., Wiemeyer S.N., Cyanide Hazards to Plants and Animals from Gold Mining and Related Water Issues, REV Environ.,183: 21-54 (2004).
[3] Miller J.D., Pyrite Depression by Reduction of Solution Oxidation Potential, Report to EPA Water Quality Office, University of Utah, Grant No. 12010 DIM, (1970).
[4] Fuerstenau M.C., Chander  S., Wood R., Sulfide Mineral Flotation, In: “Froth Flotation: A Century of Innovation”, Edited by Fuerstenau M.C., Jameson G.J., Yoon R ., SME, 425-453 (2009).
[5] Hoyack M.E., “Selective Separation of Pyrite from Sphalerite Using Sodium Sulfite”, Master of Science. Thesis, University of Arizona, (1984).
[6] Mezey E.J., Neuendorf  D.W., Simthom C.R., “Alternatives for Sodium Cyanide for Flotation Control”, Report to EPA Research and Development Office, Report No. 600/2-81-157, (1981).
[7] Rohner P., Dipasquale S., Johnson N.W., Pilot Plant Testing of Metabisulphite in the Lead Circuit for Hilton ore, In: “Processing of Complex Ores”, Edited by Dobby G.S., Rao S.R., Pergamon press, 183-192 (1989). 
[8] Grano S.R., Prestidge C.A., Ralston J., Sulphite Modification of Galena Surfaces and Its Effect on Flotation and Xanthate Adsorption, Int. J. Miner. Process, 52: 1-29 (1997).
[9] Grano S.R., Prestidge  C.A., Ralston  J., Solution Interaction of Ethyl Xanthate and Sulphite and its Effect on Galena Flotation and Xanthate Adsorption, Int. J. Miner. Process, 52: 162-186 (1996).
[10] Shen W.Z., Fornasiero D. Ralston J., Flotation of Sphalerite and Pyrite in the Presence of Sodium Sulfite, Int. J. Miner. Process, 63: 17-28 (2001).
[11] Magdalinovic N., Trumhc M., Petkovic Z., Rajic V., Cyanide Elimination From Lead-Zinc Flotation, The European Journal of Mineral Processing and Environmental Protection, 4(1): 30-35 (2004).
[12] Quast K., Hobart G., Marmatite Depression in Galena Flotation, Miner. Eng., 19(1): 860-869 (2006).
[13] Wei S., Fang S.J., Jang Z., Separation of Sulfide Lead-Zinc-Silver ore under Low Alkalinity Condition, J. Cent. South Univ., 19: 2307−2315 (2012).