Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Experimental Study of the Effect of Nanofluids Containing Activated Carbon Nanoparticles on Carbon Dioxide Absorption

Document Type : Research Article

Authors
Mina Dorost
Mohammad Bonyadi
Hakimeh Sharififard
Chemical Engineering Department, Yasouj University, Yasouj, I.R. IRAN
Abstract
Increasing greenhouse gases, especially carbon dioxide, are a serious threat to the environment and rising global temperature. One of the methods of separation and reduction of greenhouse gases is based on physical and chemical absorption by nanofluids. The main goal of this study is to investigate the effect of aqueous base nanofluids containing activated carbon nanoparticles synthesized from agricultural waste at different concentrations on CO2 absorption. For this purpose, the activated carbon nanoparticles were first synthesized from walnut shells, and the physicochemical properties of the synthesized nanoparticles were determined by FESEM, FT-IR, and BET analyses, and then the nanofluids were prepared at different concentrations of nanoparticles including 0.02, 0.05, and 0.1 wt. %. The effect of prepared nano-fluids on the carbon dioxide absorption at 35° C and pressures of 20, 30, and 40 bar were investigated in a high-pressure equilibrium cell with a magnetic stirrer and results are compared with CO2 absorption by pure water. The results showed that carbon dioxide uptake increased with increasing nanoparticle concentration and initial pressure. The maximum CO2 absorption occurred at 40 bar and 0.1 wt. % of nanoparticles, in which the CO2 absorption was 29% higher than pure water.
Keywords
Activated carbon nanoparticles
Walnut shells
Nanofluids
Absorption
Carbon dioxide
[1] Jayanthakumaran K., Verma R., Liu Y., CO2 Emissions, Energy Consumption, Trade and Income: a Comparative Analysis of China and India, Energy Policy, 42: 450-460 (2012).
[2] Breidenich C., Magraw D., Rowley A., Rubin J., The Kyoto Protocol to the United Nations Framework Convention on Climate Change, American Journal of International Law, 92(2): 315-331 (1998).
[3] Theo W.L., Lim J.S., Hashim H., Mustaffa A.A.,  Ho W.S., Review of Pre-Combustion Capture and Ionic Liquid in Carbon Capture and Storage, Applied Energy, 183: 1633-1663 (2016).
[4] نجف­لو ا.، مدل‌سازی ترمودینامیکی جذب دی اکسید کربن در محلول آبی متیل دی اتانول آمین، نشریه شیمی و مهندسی شیمی ایران، (2)38: 183 تا 194 (1388).
[5] صحرایی س.، رشیدی ح.، والهءشیدا، پیوند، بررسی اثر متغیرهای عملیاتی و بهینه سازی فرایند جذب کربن دی‌اکسید از گاز به دست آمده از احتراق توسط دی‌اتانول‌آمین با استفاده از روش سطح-پاسخ، نشریه علوم و مهندسی جداسازی، 11: 26 تا 40 (1398).
[6] Smith K.H., Anderson C.J., Tao W., Endo K., Mumford K.A., Kentish S.E.,  Stevens G.W., Pre-Combustion Capture of CO2—Results from Solvent Absorption Pilot Plant Trials Using 30 wt% Potassium Carbonate and Boric Acid Promoted Potassium Carbonate Solvent, International Journal of Greenhouse Gas Control, 10: 64-73 (2012).
[7] Yogesh G.K., Shuaib E.P., Sastikumar D., Photoluminescence Properties of Carbon Nanoparticles Synthesized from Activated Carbon Powder (4% Ash) by Laser Ablation in Solution, Materials Research Bulletin, 91: 220-226 ‏(2017).
[8] Poongavanam G.K., Ramalingam V., Characteristics Investigation on Thermophysical Properties of Synthesized Activated Carbon Nanoparticles Dispersed in Solar Glycol, International Journal of Thermal Sciences, 136: 15-32 ‏(2019).
[9] Rahmatmand B., Keshavarz P.,  Ayatollahi S., Study of Absorption Enhancement of CO2 by SiO2, Al2O3, CNT, and Fe3O4 Nanoparticles in Water and Amine Solutions, Journal of Chemical & Engineering Data, 61(4): 1378-1387 (2016).
[10] Nabipour M., Keshavarz P., Raeissi S., Experimental Investigation on CO2 Absorption in Sulfinol-M based Fe3O4 and MWCNT Nanofluids, International Journal of Refrigeration, 73: 1-10 (2017).
[11] Rashidi H., Sohrabi R., Detailed Performance Model of Carbon Dioxide Absorption Utilizing Titanium Dioxide Nanoparticles in a Wetted Wall Column, Environmental Progress Sustainable Energy, 38: 13211 (2019).
[12] Lu C., Bai H., Wu B., Su F., Hwang J.F., Comparative Study of CO2 Capture by Carbon Nanotubes, Activated Carbons, and Zeolites, Energy & Fuels, 22(5): 3050-3056 ‏(2008).
[13] Kim W.G., Kang H.U., Jung K.M., Kim S.H., Synthesis of Silica Nanofluid and Application to CO2 Absorption, Separation Science and Technology, 43(11-12): 3036-3055 (2008).
[14] Aber S., Zarei M., Niaei A., Joshani Koshky H., Effect of Carbon Nanotubes and Activated Carbon Addition to the Blends of Monoethanolamine and Triethanolamine on CO2 Absorption at Low Partial Pressures, International Journal of Energy and Environmental Engineering, 1(1): 49-55 ‏(2010).
[15] Tutuk D.K., Ahmad F.I., Nyoman I., Seno J., CO2 Removal from Biogas Using Carbon Nanotubes Mixed Matrix Membranes, International Journal of Science and Engineering, 1(1): 1-6 (2010).
[16] Razavi S.S., Hashemianzadeh S.M., Karimi H., Modeling the Adsorptive Selectivity of Carbon Nanotubes for Effective Separation of CO2/N2 Mixtures, Journal of Molecular Modeling, 17(5): 1163-1172 (2011).
[17] Jung J.Y., Lee J.W., Kang Y.T., CO2 Absorption Characteristics of Nanoparticle Suspensions in Methanol, Journal of Mechanical Science and Technology, 26(8): 2285-2290 (2012).
[18] Pineda I.T., Lee J.W., Jung I., Kang Y.T., CO2 Absorption Enhancement by Methanol-Based Al2O3 and SiO2 Nanofluids in a Tray Column Absorber, International Journal of Refrigeration, 35(5): 1402-1409 (2012).
[19] Golkhar A., Keshavarz P., Mowla D., Investigation of CO2 Removal by Silica and CNT Nanofluids in Microporous Hollow Fiber Membrane Contactors, Journal of Membrane Science, 433: 17-24 (2013).
[20] Lee J.W.,  Kang Y.T., CO2 Absorption Enhancement by Al2O3 Nanoparticles in NaCl Aqueous Solution, Energy, 53: 206-211 (2013).
[21] چالکش امیری م.، "مفاهیم انتقال جرم"، انتشارات ارکان ‏دانش (1387).
[22] Zhang Z., Cai J., Chen F., Li H., Zhang W., Qi W., Progress in Enhancement of CO2 Absorption by Nanofluids: A Mini Review of Mechanisms and Current Status, Renewable Energy, 118: 527-535 (2018).
[23] Rashidi N.A., Yusup S., An Overview of Activated Carbons Utilization for the Post-Combustion Carbon Dioxide Capture. Journal of CO2 Utilization, 13: 1-16 (2016).
[24] Bae J.S., Su S., Macadamia Nut Shell-Derived Carbon Composites for Post Combustion CO2 Capture, International Journal of Greenhouse Gas Control, 19: 174-182 (2013).
[25] Sarkar S.C., Bose A., Role of Activated Carbon Pellets in Carbon Dioxide Removal, Energy Conversion and Management, 38: 105-110 (1997).
[26] اسدی سنگاچینی ز.، یونسی ح.ا.، محمدی گلنگش ح.ا.، "تولید کربن فعال از پوسته گردو برای جذب گاز دی اکسید کربن"، هشتمین سمینار ملی شیمی و محیط زیست ایران، دانشگاه خوارزمی، کرج (1396).
[27] تمنانلو ج.، فاطمی ش.، "جذب دینامیک مخلوط گازهای هیدروژن، دی اکسید کربن و متان توسط بستر جذب کربن فعال"، پانزدهمین کنگره ملی مهندسی شیمی ایران، دانشگاه تهران، تهران (1393).
[28] Li W.Z., Xie S.S., Qian L., Chang B.H., Zou B.S., Zhou W.Y., Wang G., Large-Scale Synthesis of Aligned Carbon Nanotubes, Science, 274(5293): 1701-1703 (1996).
[29] شریفی فرد ح.، هاشمی شهرکی ز.، لشنی زادگان ا.، مدل‌سازی انتقال جرم فرایند جذب سطحی کادمیوم با کربن فعال سنتز شده از تفاله انگور، نشریه شیمی و مهندسی شیمی ایران، (3)39: 171 تا 183 (1399).
[30] Shahraki Z.H., Sharififard H., Lashanizadegan A., Grape Stalks Biomass as Raw Material for Activated Carbon Production: Synthesis, Characterization and Adsorption Ability, Materials Research Express, 5(5): 055603 (2018).
[31] Poongavanam G.K., Ramalingam V., Characteristics Investigation on Thermophysical Properties of Synthesized Activated Carbon Nanoparticles Dispersed in Solar Glycol, International Journal of Thermal Science, 136: 15-32 (2019).
[32] Darvanjooghi M.H.K., Esfahany M.N., Esmaeili-Faraj S.H., Investigation of the Effects of Nanoparticle Size on CO2 Absorption by Silica-Water Nanofluid, Separation and Purification Technology, 195: 208-215 (2018).