Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Experimental Study and Statistical Analysis of Ethane Molecular Diffusion Coefficient in N-Methyl-2-Pyrrolidone (NMP) Solvent Using Pressure Decay Method

Document Type : Research Article

Authors
Farzin Oushal
S.M. Peyghambarzadeh
shima Azizi
Zoha Azizi
Department of Chemical Engineering, Mahshahr Branch, Islamic Azad University, Mahshahr, I.R.IRAN
Abstract
Among the compounds widely used in the petrochemical industry, we can name olefins and paraffins, which are used according to their carbon content. Separation of ethane from ethylene as an important industrial product for obtaining pure ethylene is of great importance in industry. In this study, calculation and Experimental Research of molecular diffusion coefficient of ethane gas in normal methyl pyrrolidone (NMP) solvent was performed using pressure decay data in a specified time of 12 hours and Sheikhaʹs graphical method. Using the obtained molecular diffusion coefficients, the effect of temperature and pressure on the system was investigated. Also, to confirm the findings, Wilk-Chang relationship, Diaz and statistical analysis were used. According to the observations and diagrams, it can be concluded that with increasing temperature and pressure, the molecular diffusion coefficient of ethane gas in NMP solvent increases. It was also observed that the molecular diffusion coefficient of ethane gas at low pressures did not change much with increasing temperature, but with increasing pressure, increasing temperature shows its effect on the molecular diffusion coefficient. The molecular diffusion coefficients calculated by the Wilk-Chang equation do not have an acceptable overlap with the Sheikha equation, while in the Diaz experimental equation the molecular diffusion coefficients show a very good overlap with the Sheikha equation. The results of statistical analysis showed that although with increasing temperature and pressure, the molecular diffusion coefficient of ethane gas in the solvent increases, but the effect of increasing pressure on the gas diffusion in the solvent is greater than the effect of temperature. The effect of temperature and pressure interaction on the molecular diffusion coefficient of ethane gas, although small, is present and affects the gas diffusion in the solvent.
Keywords
Molecular diffusion coefficient
Pressure decay
Statistical analysis
Ethane

Subjects

[1] Düren T., Sarkisov L., Yaghi O.M., Snurr R.Q., Design of New Materials for Methane Storage, Langmuir, 20: 2683–2689 (2004(.
[2] Wagner H., Luther R., Mang T., Lubricant base Fluids based on Renewable Raw Materials: Their Catalytic Manufacture and Modification, Applied Catalysis A: General, 221: 429–442 (2001).
[3] Harifi-Mood A.R., Solubility of Carbon Dioxide in Binary Mixtures of Dimethyl Sulfoxide and Ethylene Glycol: LFER Analysis, J. Chem. Thermodynamic (JCT), 141: 105968 (2020).
 [4] Azizi S.,  Dezfuli H.T., Kargari A., Peyghambarzadeh S.M., Experimental Measurement and thermodynamic Modeling of Propylene and Propane Solubility in N-Methyl Pyrrolidone (NMP), Fluid Phase Equilib, 387:190–197 (2015) .
[5] Bohloul M., Sadeghabadi M.A., Peyghambarzadeh S.M., Dehghani M., CO2 Absorption using Aqueous Solution of Potassium Carbonate: Experimental Measurement and Thermodynamic Modeling, Fluid Phase Equilib, 447: 132–141 (2017).
[6] Bohloul M., Vatani A., Peyghambarzadeh S.M., Experimental and Theoretical Study of CO2 Solubility in N-Methyl-2-Pyrrolidone (NMP), Fluid Phase Equilib, 365: 106–111 (2014).
 [7] Behrouz M., Aghajani M., Solubility of Methane, Ethane, and Propane in Pure Water using New Binary Interaction Parameters, Iran. J. Oil Gas Sci. Technol, 4(3): 51–59 (2015).
 [8] Cancelas A.J., Plata M.A., Bashir M.A., Bartke M., Monteil V., McKenna T.F., Solubility and Diffusivity of Propylene, Ethylene, and Propylene–Ethylene Mixtures in Polypropylene, Macromol Chem. Phys, 21(8): 1700565 (2018) .
[9] Riazi M., A New Method for Experimental Measurement of Diffusion Coefficients in Reservoir Fluids, J. Pet. Sci. Eng, 14: 235-250 (1996).
[10] Sanders D., Freeman B., Energy-Efficient Polymeric Gas Separation Membranes for a Sustainable Future: A Review, Polymer, 54: 4729-4761 (2013).
[11] Buonomenna M.G., Membrane Processes for a Sustainable Industrial Growth, RSC Advances, 3:  5694-5740 (2013).
[12] Etminan R., Maini B., Chen Z., Hassanzadeh H., Constant-Pressure Technique for Gas Diffusivity and Solubility Measurements in Heavy Oil and Bitumen, Energy & Fuels, 24: 533-549 (2010).
[13] Zhang Y., Hyndman C., Maini B., Measurement of Gas Diffusivity in Heavy Oils, J. Pet. Sci. Eng, 25: 37-47 (2000).
[14] Sheikha H., Pooladi-Darvish M., Mehrotra A., Development of Graphical Methods for Estimating the Diffusivity Coefficient of Gases in Bitumen from Pressure-Decay Data, Energy & Fuels, 19(5): 2041–2049 (2005).
[15] Kavousi A., Torabi F.,  Chan Ch.W.,  Shirif E., Experimental Measurement and Parametric Study of CO2  Solubility and Molecular Diffusivity in Heavy Crude Oil Systems, Fluid Phase Equilibria, 371: 57–66 (2014).
[16] Azizi S., Kargari A., Kaghazchi T., Experimental and Theoretical Investigation of Molecular Diffusion Coefficient of Propylene in NMP, Chemical Engineering Research and Design, 92: 1201–1209 (2014).
[17] Gholami Y.,  Azin R., Fatehi R.,  Osfouri Sh.,  Bahadori A., Prediction of Carbon Dioxide Dissolution in Bulk Water under Isothermal Pressure Decay at Different Boundary Conditions, Journal of Molecular Liquids, 202: 23–33 (2015).
[18] Gholami F., Azizi S., Peyghambarzadeh S.M., Bohloul M.R., The Modelling and Experimental Study on Molecular Diffusion Coefficient of CO2 in N-Methyl Pyrolidone, Separation Science and Technology, 52: 2435-2442 (2017).
[19] Yang Z., Bryant S., Dong M., Hassanzadeh H., An Analytical Method of Estimating Diffusion Coefficients of Gases in Liquids from Pressure Decay Tests, AIChE Journal, 65: 434-445 (2019).
[20] Azizi S., Evaluation of Mass Transfer Resistance Across the Interface for CO2-Propylene Carbonate System: Experimental and Mathematical Modeling, Chemical Engineering Research and Design, 149: 34-44 (2019).
[21] Yousefi M., Azizi S., Peyghambarzadeh S.M., Azizi Z., Intensification of Ethylene and Ethane Absorption in N-Methyl-2-Pyrrolidone (NMP) by Adding Silver Nanoparticles, Chemical Engineering and Processing - Process Intensification, 158: 108184 (2020).
[22] Afanasenko L.D., Yarym Agaev N.L., Korotkova E.V., Viscosimetric Properties of the System Diethylene Glycol - n-Methylpyrrolidone –Water, Zh. Prikl. Khim, 58: 2291-2296 (1985).
[23] Langan J.R., Salmon G.A., Physical Properties of N-Methylpyrrolidinone as Functions of Temperature, J. Chem. Eng. Data, 32: 420-422 (1987).
[24] Vodolazhskii S.V., Yakushkin M.I., Golobacheva O.I., Gaile A.A., Production and Application of p-Dioxan-2-one, 3-Morpholinone, n-Methyl-3-Morpholinone, Khim. Prom, 434-435 (1994).
[25] Ambrosone L., D'Errico G., Sartorio R., Vitagliano V., Analysis of Velocity Cross-correlation and Preferential Solvation for the System N-Methylpyrrolidone-Water at 20 °C, J. Chem. Soc. Faraday Trans,  91: 1339-1344 (1995).
[26] Diaz M., Vega A., Coca J., Correlation for the Estimation of Gas-Liquid Diffusivity, Chemical Engineering Communications, 52: 271-281 (1987).
[27] Saltzman E.S., King D.B., Holmen K., Leck C., Experimental Determination of the Diffusion Coefficient of Dimethylsulfide in Water, Journal of Geophysical Research, 98(C9): 16481-16486 (1993).
[28] Hayduk W., Cheng S.C., Review of Relation between Diffusivity and Solvent Viscosity in Dilute Liquid Solutions, Chemical Engineering Science, 26: 635-646 (1971).  
[29] Miyabe K., Isogai R., Estimation of Molecular Diffusivity in Liquid Phase Systems by the Wilke–Chang Equation, Journal of Chromatography A, 1218: 6639-6645 ( 2011).
[30] Li J., Carr P.W., Accuracy of Empirical Correlations for Estimating Diffusion Coefficients in Aqueous Organic Mixtures , Anal. Chem, 69(13): 2530-2536 (1997).
[31] Young M.E., Carroad  P.A., Bell R.L., Estimation of Diffusion Coefficients of Proteins, Biotechnology and Bioengineering, 22(5): 947-955 ( 1980).
[32] Akgerman A.,  Gainer J.L., Diffusion of Gases in Liquids, Ind. Eng. Chem. Fund, 11(3): 373-379 (1972).
[33] Sitaraman R., Ibrahim S.H., Kuloor N.R., A Generalized Equation for Diffusion in Liquids, J. Chem. Eng. Data, 8(2): 198-201(1963).
[34] Azin R., Mahmoudy M., Raad S.M.J., Osfouri S., Measurement and Modeling of CO2 Diffusion coefficient in Saline Aquifer at Reservoir Conditions, Cent. Eur. J. Eng, 3(4): 585-594 (2013).
[35] Shokouhi M., Koolivand Salooki M., Sadeghzadeh Ahari J., Esfandyari M., Thermodynamical and Artificial Intelligence Approaches of H2S Solubility in N-Methylpyrrolidone, Chem. Phys. Letters, 707: 22–30 (2018).