Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Evaluation of the Effect of Cold Plasma on the Shelf Life of Oyster Mushrooms

Document Type : Research Article

Authors
Erfun Shabani 1
Ali Reza Shahab Lavasani 1
Mahmoud Habibian 2
Mohammad Reza Eshaghi 1
Sara Movahed 1
1 Department of Food Sciences and Technology, Faculty of Agriculture, Varamin-Pishva Branch, Islamic Azad University, Varamin, I.R. IRAN
2 Chemistry and Chemical Engineering Research Center of Iran, Tehran, I.R. IRAN
Abstract
Cold plasma is one of the food preservation methods in the food industry, which increases the shelf life of food products, the purpose of this research is to investigate the increase in shelf life of oyster mushrooms under cold plasma treatment under the treatment of two gases (argon and air) for the duration of (0, 5, 10, 20) minutes at the pressure of 1 torr and the power of 100 watts, the surface of oyster mushroom was exposed to cold plasma radiation, which led to a decrease in the total count, coliform, mold and yeast and Pseudomonas syringic PV. The results of microbial and physical analyses showed that in five minutes under cold plasma treatment, excited gases of argon and air reduced the microbial load by 99% and caused the least effect on the physical and appearance properties of oyster mushroom products. In the examination of the physical properties of oyster mushrooms (texture and weight), it was shown that the effect of gas type had a significant effect on these indicators. And about ten percent performance improvement. Increasing plasma treatment time to twenty minutes led to a significant difference (p<0.05). Examining the type of gas and its effect on the treatment showed that the type of gas makes a significant difference and the effectiveness of air gas is slightly higher than argon in the overall count (p<0.05). Cold will be a suitable and low-cost method for sterilizing and pasteurizing mushrooms to increase their shelf life.
Keywords
Shelf life
Oyster mushroom
Cold plasma

Subjects

[1] مظلوم س.، فلاح شجاعی.، حسن ک.، میرزایی, ح.ا.، مروری بر امکان استفاده از فنّاوری پلاسمای سرد در صنعت بسته بندی، فصلنامه علمی علوم و فنون بسته بندی، 14(4): 23 (1392)
[2] صحبت زاده، ف.، میرزا نژاد، س.، مهدوی، ه.، بررسی پلاسمای سرد اتمسفری در فرکانس رادیویی 56/13 مگاهرتز. مقاله نامه کنفرانسی فیزیک ایران، فیزیک اتمی و مولکولی، 1637-1640 (1390)
[3] بی نام، میکروبیولوژی مواد غذایی و خوراک دام، روش جامع برای شمارش کپک و مخمرها، شماره 10899-1، موسسه استاندارد و تحقیقات صنعتی ایران
[4] بی نام، بی نام، کیفیت آب، شمارش میکروارگانیزم های قابل کشت-شمارش کلنی با استفاده از تلقیح در محیط کشت آگار مغذی، شماره 5271، سازمان ملی استاندارد ایران
[5] Mishra S.K., Shikha M., "An Analytical Investigation: Effect of Solar Wind on Lunar Photoelectron Sheath." Physics of Plasmas 25(2): 023702 (2018).
[6] Govindan S.V., Cardillo T.M., Moon S.J., Hansen H.J., Goldenberg DM. CEACAM5-Targeted Therapy of Human Colonic and Pancreatic Cancer Xenografts with Potent Labetuzumab-SN-38 Immunoconjugates. Clinical Cancer Res earch. 15(19): 6052-6061 (2009).
[7] Law AK., Hui Y.V., Zhao X., Modeling Repurchase Frequency and Customer Satisfaction for Fast Food Outlets. International journal of quality & reliability management. 21(5): 545-63 (2004).
[8] Shi T.Q., Shi T.Q., Liu G.N., Ji R.Y., Shi K., Song P., Ren L.J., Huang He., Ji XiaoJun., "CRISPR/Cas9-Based Genome Editing of the Filamentous Fungi: the State of the Art." 7435-7443 (2017).
 [9] Gilany K., Mani‐Varnosfaderani A., Minai‐Tehrani A., Mirzajani F., Ghassempour A., Sadeghi M.R., Amini M., Rezadoost H., Untargeted Metabolomic Profiling of Seminal Plasma in Nonobstructive Azoospermia Men: A Noninvasive Detection of Spermatogenesis. Biomedical Chromatography. 31(8): e3931 (2017).
[10]. Ouf S.A., Basher A.H., Mohamed A.A., Inhibitory Effect of Double Atmospheric Pressure Argon Cold Plasma on Spores and Mycotoxin Production of Aspergillus Niger Contaminating Date Palm Fruits. Journal of the Science of Food and Agriculture. 95(15): 3204-3210 (2015).
[11] Kader A., Importance of Fruits, Nuts, and Vegetables in Human Nutrition and Health. Perishables handling quarterly. 106(4): 6 (2001).
[12] D'Aquino S, Continella A, Gentile A, Dai S, Deng Z, Palma A. Decay Control and Quality of Individually Film-Wrapped Lemons Treated with Sodium Carbonate. Food Control. 108: 106878 (2020).
[13] Law A.K., Hui Y.V., Zhao X., Modeling Repurchase Frequency and Customer Satisfaction for Fast Food Outlets. International journal of quality & reliability management. 21(6): 545-563 (2004).
[14] Nam-Trung N., Wereley S.T., Mousavi Shaegh S.A. Fundamentals and Applications of Microfluidics. Artech house, (2019).
[15] Xiao J, Huang X, Alkhers N, Alzamil H, Alzoubi S, Wu TT, Castillo DA, Campbell F, Davis J, Herzog K, Billings R. Candida Albicans and Early Childhood Caries: A Systematic Review and Meta-Analysis. Caries research. 52(1-2): 102-112 (2018).
[16] Javanmardi J, Kubota C. Variation of Lycopene, Antioxidant Activity, Total Soluble Solids and Weight Loss of Tomato During Postharvest Storage. Postharvest biology and technology. 41(2): 151-5 (2006).
[17] Misra NN, Patil S, Moiseev T, Bourke P, Mosnier JP, Keener KM, Cullen PJ. In-Package Atmospheric Pressure Cold Plasma Treatment of Strawberries. Journal of Food Engineering. 125: 131-8 (2014).
[18] Rux G., Mahajan P.V., Geyer M., Linke M., Pant A., Saengerlaub S., Caleb OJ., Application of Humidity-Regulating Tray for Packaging of Mushrooms. Postharvest Biology and Technology. 108: 102-10 (2015).
[19] Kader Adel., "Importance of Fruits, Nuts, and Vegetables in Human Nutrition and Health." Perishables handling quarterly, 106(4): 6 (2001).
[20] Ben-Yehoshua S., Barak E., Shapiro B., Postharvest Curing at High Temperatures Reduces Decay of Individually Sealed Lemons, Pomelos, and Other Citrus Fruit. Journal of the American Society for Horticultural Science. 112(4): 658-663 (1987).
[21] Ouf Salama A., Abdulrahman H. Basher., Abdel‐Aleam H. Mohamed., "Inhibitory Effect of Double Atmospheric Pressure Argon Cold Plasma on Spores and Mycotoxin Production of Aspergillus Niger Contaminating Date Palm Fruits." Journal of the Science of Food and Agriculture, 95(15): 3204-3210 (2015).
[22] Pourbagher R., Abbaspour‐Fard M.H., Khomeiri M., Sohbatzadeh F., Rohani A., Effects of Gas Type and Cold Plasma Treatment Time on Lecanicillium Fungicola Spores Reduction and Changes in Qualitative, Chemical, and Physiological Characteristics of Button Mushroom During Postharvest Storage. Journal of Food Processing and Preservation. 46(10): e16901 (2022).
[23] Zhu Y., Elliot M., Zheng Y., Chen J., Chen D., Deng S., Aggregation and Conformational Change of Mushroom (Agaricus Bisporus) Polyphenol Oxidase Subjected to Atmospheric Cold Plasma Treatment. Food Chemistry. 386: 132707 (2022).