Nashrieh Shimi va Mohandesi Shimi Iran

Nashrieh Shimi va Mohandesi Shimi Iran

Experimental Investigation of the Thermal Performance of a Two-Phase Closed Thermosyphon under Developed and Geyser Boiling Phenomena in the Evaporator Section

Document Type : Research Article

Authors
Hasan Khodadi
Mohammad Reza Sarmasti Emami
Chemical Engineering Department, University of Science and Technology of Mazandaran, Behshahr, I.R. IRAN
Abstract
Energy conservation is becoming increasingly important as the cost of fuel continuously rises. The two-phase closed thermosyphons are handy tools in the heat transfer process. In this study, the effect of affecting parameters on a two-phase closed thermosyphon's thermal performance was investigated experimentally. A copper pipe with a length of one meter and an inside diameter of 20 mm was constructed. Distilled water was used as a working fluid for this research. Many experiments were carried out for the inclination angle range of 5º–90º, input heat between 100 to 300 W, aspect ratio 13, 16.5, 20, and filling ratios of 25% to 70%. An experimental correlation derived from all of the results shows that the thermal efficiency increase with the increase of the filling ratio, mass flow rate of the coolant, and input heat and decreases with the rise in the inclination angle and aspect ratio. The highest thermal efficiency is obtained at input power 200 W, inclination angle 60, aspect ratio 16.5, and the filling ratio 50%. The geyser boiling has been investigated by examining the time variations of the outlet water temperature from the condenser jacket. At an input power of 100W, geyser boiling occurs, but if input power equal to or greater than 150 W combined, boiling will be observed. An empirical relationship for the period of temperature variations caused by boiling was presented. The results show that the geyser boiling period was shorter for higher input power, cooling water flow rate, and inclination angles.
Keywords
Two-phase closed thermosyphon
Thermal efficiency
Aspect ratio
Filing ratio
Developed boiling
Geyser boiling

Subjects

[1] Faghri A., "Heat Pipe Science and Technology", Global Digital Press, USA (2016).
[2] Zare Aliabadi H., Atashy H., Noie S.H., Khoshnoodi M., Khorram M., Khoshvaght M., Experimental and Numerical Analysis of Flow and Heat Transfer in a Gas-Liquid Thermosyphon Heat Exchanger in a Pilot Plant, Iran. J. Chem. Chem. Eng. (IJCCE), 29 (2): 121-129 (2010).
[3] Jafari D., Franco A., Filippeschi S.  Di Marco P., Two-Phase Closed Thermosyphons: A Review of Studies and Solar Applications, Renewable and Sustainable Energy Reviews, 53:575-593 (2016).
[4] Ma C., Wu X., Gao S., Analysis and Applications of a Two-Phase Closed Thermosyphon for Improving the Fluid Temperature Distribution in Wellbores, Applied Thermal Engineering, 55 (1–2):1-6 (2013).
[5] خزایی، ا.، حسینی، ر.، بهرامیان، ع.، "بررسی تجربی خصوصیات گرمایی، رژیم‌های جوشش و جوشش نوسانی در یک ترموسیفون دوفازی بسته"، دوازدهمین کنفرانس دینامیک شاره‌ها، 10-8 اردیبهشت، دانشگاه صنعتی نوشیروانی، بابل، 1388.
[6] Negishi K., Sawada T., Heat Transfer Performance of an Inclined Two-Phase Closed Thermosyphon, Int. J. Heat Mass Transfer, 26(8):1207-1213 (1983).
[7] Negishi K., "Unstable Phenomena in a Two-Phase Closed Thermosyphon", Proc. Symp. on Mechanics for Space Flight, August 22-24, Lake Placid, NY (1983).
[8] Negishi K., "Thermo-Fluid Dynamics of Two-Phase Closed Thermosyphons", Proc. 5th IHPC, 1984.
[9] Lin T.F., Lin W.T., Tsay Y.L., Wu J.C., Experimental Investigation of Geyser Boiling in an Annular Two Phase Closed Thermosyphon, Int. J. Heat Mass Transfer, 38(2):295-307 (1995).
[10] Kunkoro H., Rao Y.F., Fukuda K., An Experimental Study on the Mechanism of Geysering in a Closed Two Phase Thermosyphon, Int. J. of Multiphase Flow, 21(6):1243-1252 (1995).
[11] سرمستی امامی م. ر.، نوعی، س. ح.؛ خشنودی م.، نعمتی م.، "بررسی جوشش نوسانی در یک ترموسیفون دوفازی بسته"، دهمین کنگره ملی مهندسی شیمی ایران، 24-26 آبان، دانشگاه سیستان و بلوچستان، زاهدان، ایران (1384).
[12] Sarmasti Emami M.R., Noie S.H., Khoshnoodi M., Hamed Mosavian M.T. , Kianifar A., Investigation of Geyser Boiling Phenomenon in a Two-Phase Closed Thermosyphon, Heat Transf. Eng., 30(5):408–415 (2009).
[13] Khazaee I., Hosseini R. Noie S.H., Experimental Investigation of Effective Parameters and Correlation of Geyser Boiling in a Two-Phase Closed Thermosyphon, Applied Thermal Eng., 30:406–412 (2010).
[14] Tian F.Z., Xin G.M., Wang X.Y. Cheng L., An Investigation of the Unstable Oscillation Phenomenas of Two-Phase Closed Thermosyphon, Adv. Materials Research, 668: 608-611 (2013).
[15] Grab C., Kulenovic R., Starflinger J., "Experimental Investigation on Long Two-Phase Closed Thermosiphons to be Applied in Spent Fuel Pools for Passive Heat Removal", 26th Int. Conf. Nuclear Energy for New Europe, September 11-14, Bled, Slovenia (2014).
[16] Smith K., Kempers R., Robinson A.,"Boiling and Condensation in Small Diameter Closed Two-Phase Thermosyphons", 9th Int. Conf. on Boiling and Condensation Heat Transfer, April 26-30, Boulder, Colorado (2015).
[17] Jouhara, H., Fadhl, B., C. Wrobel, L., Three-Dimensional CFD Simulation of Geyser Boiling in a Two-Phase Closed Thermosyphon, Int. J. of Hydrogen Energy, 41(37):16463-16476 (2016). 
[18] Wang X. , Wang Y.,  Chen H.,  Zhu Y., A Combined CFD/Visualization Investigation of Heat Transfer Behaviors During Geyser Boiling in Two-Phase Closed Thermosyphon, Int. J. of Heat and Mass Transfer, 121:703–714 (2018).
[19] Holman, J. D., "Experimental Methods for Engineers", 5th ed., Mc. Grow-Hill, New York, USA (1989).
[20] کاهانی م.، نوعی س. ح.، زینالی هریس س.، مقایسه عملکرد گرمایی یک ترموسیفون دوفازی بسته در اثر استفاده از نانو سیال‌های اکسید فلزی، نشریه جداسازی و پدیده­های انتقال، 21(1): 43 تا 58 (۱۳۸۹).
[21] Lin, M.C., Chun, L. J., Lee, W. S. and Chen, S. L., Thermal Performance of a Two-Phase Thermosyphon Energy Storage System, Solar Energy, 75(4): 295-306 (2003).
[22] شبندی م.، زینالی هریس س.، بنی آدم م.، امیری ا.، "بهبود عملکرد گرمایشی ترموسیفون بسته دوفازی (TPCT) بر اثر افزودن نانولوله کربنی به آب دیونیزه"، سومین کنفرانس بین المللی گرمایش، سرمایش و تهویه مطبوع، 5-3 خرداد، تهران (1390).
[23] نوعی س. م.، نوعی س. ح.، حریری دیبا ف.، بررسی تجربی عملکرد نانو سیال اکسید مس ـ استون بر بازده گرمایی یک ترموسیفون دوفازی بسته، نشریه شیمی و مهندسی شیمی ایران، 32 (3): 31 تا 38 (1392).
[24] Parate H. Farkade, S., Thermal Performance of a Two Phase Closed Thermosyphon Using Nanofluid, Int. J. for Scientific Research & Development, 2(4):8-11 (2014).
[25] Noie S.H., Zeinali Heris S., Kahani M., Nowee S.M., Heat Transfer Enhancement Using Al2O3/Water Nanofluid in a Two-Phase Closed Thermosyphon, Int. J. of Heat and Fluid Flow, 30:700-705 (2009).